2010 Chevrolet Crash Tests, Recalls and Service Bulletins, 2009 Chevrolet Crash Tests, Recalls and Service Bulletins

Component:

Manufacturer:

Manufacture Dates:

Potential Units Affected:

GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.

WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.

ELECTRICAL SYSTEM:BATTERY:CABLES

DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET C5500

NHTSA Campaign ID:

09V091000

Component:

Manufacturer:

LDV, INC.

Manufacture Dates:

01/01/2007 - 03/06/2009

Potential Units Affected:

LDV IS RECALLING 81 TRUCKS BUILT ON CHEVROLET AND FORD MY 2007-2009 C5500, MY 2008-2009 W5500, AND MY 2008 F-650 CHASSIS SPECIFICALLY FOR SNAP-ON TOOLS FOR USE AS A MOBILE SUPPLY COMPANY. THERE MAY BE A CABLE INSTALLED ON THE BATTERY ISOLATOR WITH THE BODY OF THE CABLE LUG FACING THE ISOLATOR. WITH ALL CABLES TIGHTENED DOWN ON THE STUD, THIS CABLE LUG MAY BE PRESSED AGAINST THE COOLING FINS OF THE ISOLATOR, WHERE CONTACT POSES A RISK OF ELECTRICAL SHORT WHICH COULD RESULT IN CABLES OVERHEATING.

THIS CONTACT POSES A RISK OF ELECTRICAL SHORT WHICH COULD RESULT IN CABLES OVERHEATING AND A FIRE COULD OCCUR.

DEALERS WILL CONDUCT A TWO-STEP REMEDY. THE FIRST STEP IS TO INSPECT THE CABLE INSTALLATION TO ENSURE ALL CABLES ARE INSTALLED WITH THE LUG BODY FACING AWAY FROM THE ISOLATOR WITH NONE IN CONTACT WITH THE COOLING FINS. THE SECOND STEP IS TO ADD A GROUNDING STRAP OR ABLE TO HE ALUMINUM BOX TO PROPERLY GROUND IT AND THE COMPONENTS MOUNTED WITHIN IT. THE RECALL BEGAN ON MARCH 6, 2009. OWNERS MAY CONTACT LDV AT 608-257-3911.

2009 CHEVROLET COBALT

NHTSA Campaign ID:

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

Component:

Manufacturer:

Manufacture Dates:

Potential Units Affected:

GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".

THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET COLORADO

NHTSA Campaign ID:

09V310000

Component:

Manufacturer:

Manufacture Dates:

06/01/2008 - 06/30/2009

Potential Units Affected:

185903

GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.

THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.

DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY FEBRUARY 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET COLORADO

NHTSA Campaign ID:

Component:

Manufacturer:

Manufacture Dates:

Potential Units Affected:

GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.

WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.

DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET EXPRESS

NHTSA Campaign ID:

09V272000

Component:

EQUIPMENT ADAPTIVE

Manufacturer:

MAIN MOBILITY, INC.

Manufacture Dates:

04/01/2005 - 06/25/2009

Potential Units Affected:

185

MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.

2009 CHEVROLET EXPRESS

NHTSA Campaign ID:

09V270000

Component:

EQUIPMENT ADAPTIVE

Manufacturer:

MAIN MOBILITY, INC.

Manufacture Dates:

04/01/2005 - 06/25/2009

Potential Units Affected:

185

MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.

2009 CHEVROLET HHR

NHTSA Campaign ID:

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

Component:

Manufacturer:

Manufacture Dates:

Potential Units Affected:

GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".

THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.

DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET IMPALA

NHTSA Campaign ID:

08V517000

Component:

AIR BAGS:FRONTAL

Manufacturer:

Manufacture Dates:

07/01/2008 - 09/30/2008

Potential Units Affected:

GM IS RECALLING 79 MY 2009 CHEVROLET IMPALA VEHICLES. SOME OF THESE VEHICLES HAVE A PASSENGER-SIDE FRONT AIR BAG INFLATOR THAT COULD FRACTURE AT AN INFLATOR TUBE DURING A DEPLOYMENT.

DURING A PASSENGER-SIDE AIR BAG DEPLOYMENT, PIECES OF THE INFLATOR TUBE COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE PASSENGER.

VISIBILITY:DEFROSTER/DEFOGGER SYSTEM

DEALERS WILL INSTALL A NEW PASSENGER-SIDE FRONT AIR BAG. THE RECALL BEGAN ON OCTOBER 10, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT HTTP://WWW.GMOWNERCENTER.COM .

2009 CHEVROLET MALIBU

NHTSA Campaign ID:

08V634000

Component:

Manufacturer:

Manufacture Dates:

08/14/2008 - 09/19/2008

Potential Units Affected:

GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.

IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.

DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT HTTP://WWW.GMOWNERCENTER.COM .

2009 CHEVROLET MALIBU

NHTSA Campaign ID:

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

Component:

Manufacturer:

Manufacture Dates:

Potential Units Affected:

GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".

THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.

DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET SUBURBAN

NHTSA Campaign ID:

Component:

Manufacturer:

Manufacture Dates:

Potential Units Affected:

GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.

WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.

DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET TAHOE

NHTSA Campaign ID:

Component:

Manufacturer:

Manufacture Dates:

Potential Units Affected:

GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.

WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.

SEAT BELTS: REAR:BUCKLE ASSEMBLY

DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET TRAVERSE

NHTSA Campaign ID:

08V615000

Component:

Manufacturer:

Manufacture Dates:

07/01/2008 - 10/31/2008

Potential Units Affected:

16667

GM IS RECALLING 16,667 MY 2009 BUICK ENCLAVE, CHEVROLET TRAVERSE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES FOR FAILING TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, 'SEAT BELT ASSEMBLIES.' THESE VEHICLES MAY HAVE BEEN BUILT WITH A SAFETY BELT BUCKLE IN THE SECOND OR THIRD ROW THAT IS MISSING A RIVET.

IN A VEHICLE CRASH, IF THE RIVET IS MISSING, THE BUCKLE MAY SEPARATE FROM THE MOUNTING STRAP, INCREASING THE RISK OF INJURY TO THE PASSENGER.

DEALERS WILL INSPECT THE SAFETY BELT BUCKLES IN THE SECOND AND THIRD ROWS, AND REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 26, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; SATURN AT 1-800-972-8876; OR THROUGH THEIR WEBSITE AT HTTP://WWW.GMOWNERCENTER.COM .

2009 CHEVROLET TRAVERSE

NHTSA Campaign ID:

09V153000

Component:

PARKING BRAKE

Manufacturer:

Manufacture Dates:

11/01/2008 - 12/31/2008

Potential Units Affected:

15393

GM IS RECALLING 15,393 MY 2009 CHEVROLET TRAVERSE VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THESE VEHICLES MAY HAVE A PARK BRAKE CABLE LINK (CONNECTOR) THAT IS NOT TO SPECIFICATION. THIS CONNECTOR MAY FRACTURE WHEN THE PARK BRAKE PEDAL IS DEPRESSED.

IF THE TRANSMISSION SHIFT LEVER IS IN THE PARK POSITION, THERE WILL BE NO UNINTENDED VEHICLE MOVEMENT. HOWEVER, IF THE KEYS ARE LEFT IN THE IGNITION, THE TRANSMISSION SHIFT LEVER IS IN ANY POSITION OTHER THAN PARK, AND THE VEHICLE IS PARKED ON A SUFFICIENT SLOPE, IT COULD RESULT IN UNINTENDED VEHICLE MOVEMENT. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.

DEALERS ARE TO REPLACE THE PARK BRAKE CABLE LINK (CONNECTOR) FREE OF CHARGE. GM ANTICIPATES THAT THE DEALER BULLETIN WILL BE SENT MAY 5, 2009 AND OWNER LETTERS WILL BE MAILED IN JUNE 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET TRAVERSE

NHTSA Campaign ID:

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

Component:

Manufacturer:

Manufacture Dates:

Potential Units Affected:

GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".

THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.

POWER TRAIN:DRIVELINE:DRIVESHAFT

DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.

2009 CHEVROLET W3500

NHTSA Campaign ID:

09V042000

Component:

Manufacturer:

ISUZU MANUFACTURING SERVICES OF AMERICA

Manufacture Dates:

02/01/2008 - 03/31/2008

Potential Units Affected:

2836

IZUSU IS RECALLING 2,836 MY 2008-2009 NPR/NQR AND NRR, GMC W3500, 4500 AND 5500, CHEVROLET W3500, 4500 AND 5500 TRUCKS. THE PROPELLER SHAFT WAS MANUFACTURED WITH INSUFFICIENT HIGH FREQUENCY HEAT TREATMENT. AS A RESULT, THE AFFECTED PORTION OF THE PROPELLER SHAFT MAY NOT MAINTAIN ITS DURABILITY THROUGH THE EXPECTED VEHICLE USEFUL LIFE.

THE PROPELLER SHAFT COULD BREAK OFF WHILE THE VEHICLE IS BEING DRIVING, WHICH WOULD RESULT IN THE VEHICLE STALLING AND COASTING TO A STOP, OR LOSS OF VEHICLE CONTROL WHICH COULD RESULT IN A CRASH.

POWER TRAIN:DRIVELINE:DRIVESHAFT

DEALERS WILL REPLACE THE PROPELLER SHAFT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2009. OWNERS MAY CONTACT ISUZU AT 1-866-441-9638.

2009 CHEVROLET W4500

NHTSA Campaign ID:

09V042000

Component:

Manufacturer:

ISUZU MANUFACTURING SERVICES OF AMERICA

Manufacture Dates:

02/01/2008 - 03/31/2008

Potential Units Affected:

2836

IZUSU IS RECALLING 2,836 MY 2008-2009 NPR/NQR AND NRR, GMC W3500, 4500 AND 5500, CHEVROLET W3500, 4500 AND 5500 TRUCKS. THE PROPELLER SHAFT WAS MANUFACTURED WITH INSUFFICIENT HIGH FREQUENCY HEAT TREATMENT. AS A RESULT, THE AFFECTED PORTION OF THE PROPELLER SHAFT MAY NOT MAINTAIN ITS DURABILITY THROUGH THE EXPECTED VEHICLE USEFUL LIFE.

THE PROPELLER SHAFT COULD BREAK OFF WHILE THE VEHICLE IS BEING DRIVING, WHICH WOULD RESULT IN THE VEHICLE STALLING AND COASTING TO A STOP, OR LOSS OF VEHICLE CONTROL WHICH COULD RESULT IN A CRASH.

POWER TRAIN:DRIVELINE:DRIVESHAFT

DEALERS WILL REPLACE THE PROPELLER SHAFT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2009. OWNERS MAY CONTACT ISUZU AT 1-866-441-9638.

2009 CHEVROLET W5500

NHTSA Campaign ID:

09V042000

Component:

Manufacturer:

ISUZU MANUFACTURING SERVICES OF AMERICA

Manufacture Dates:

02/01/2008 -

Potential Units Affected:

2836

IZUSU IS RECALLING 2,836 MY 2008-2009 NPR/NQR AND NRR, GMC W3500, 4500 AND 5500, CHEVROLET W3500, 4500 AND 5500 TRUCKS. THE PROPELLER SHAFT WAS MANUFACTURED WITH INSUFFICIENT HIGH FREQUENCY HEAT TREATMENT. AS A RESULT, THE AFFECTED PORTION OF THE PROPELLER SHAFT MAY NOT MAINTAIN ITS DURABILITY THROUGH THE EXPECTED VEHICLE USEFUL LIFE.

THE PROPELLER SHAFT COULD BREAK OFF WHILE THE VEHICLE IS BEING DRIVING, WHICH WOULD RESULT IN THE VEHICLE STALLING AND COASTING TO A STOP, OR LOSS OF VEHICLE CONTROL WHICH COULD RESULT IN A CRASH.

ELECTRICAL SYSTEM:BATTERY:CABLES

DEALERS WILL REPLACE THE PROPELLER SHAFT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2009. OWNERS MAY CONTACT ISUZU AT 1-866-441-9638.

2009 CHEVROLET W5500

NHTSA Campaign ID:

09V091000

Component:

Manufacturer:

LDV, INC.

Manufacture Dates:

01/01/2007 - 03/06/2009

Potential Units Affected:

LDV IS RECALLING 81 TRUCKS BUILT ON CHEVROLET AND FORD MY 2007-2009 C5500, MY 2008-2009 W5500, AND MY 2008 F-650 CHASSIS SPECIFICALLY FOR SNAP-ON TOOLS FOR USE AS A MOBILE SUPPLY COMPANY. THERE MAY BE A CABLE INSTALLED ON THE BATTERY ISOLATOR WITH THE BODY OF THE CABLE LUG FACING THE ISOLATOR. WITH ALL CABLES TIGHTENED DOWN ON THE STUD, THIS CABLE LUG MAY BE PRESSED AGAINST THE COOLING FINS OF THE ISOLATOR, WHERE CONTACT POSES A RISK OF ELECTRICAL SHORT WHICH COULD RESULT IN CABLES OVERHEATING.

THIS CONTACT POSES A RISK OF ELECTRICAL SHORT WHICH COULD RESULT IN CABLES OVERHEATING AND A FIRE COULD OCCUR.